Where is the Opel Astra J fuel filter located and how is it replaced (gasoline, diesel): instructions, photos. video

During the systematic refueling of a vehicle with low-quality fuel, sediment forms at the bottom of the tank and the line becomes clogged. Passive acceleration dynamics and increased gasoline consumption are the first signs of a decrease in the throughput of the TF.

In cars of the Opel family of modifications Astra N, Astra J, Astra G, fuel filters (hereinafter referred to as TF) are installed in the following order:

gasoline engines: TF is built into the housing with a fuel pump, non-separable design, must be replaced as an assembly;
diesel: the TF is autonomous from the power unit. As a rule, it is fixed at a safe distance from the fuel rail and injectors.

For the purpose of prevention, use the inspection channel, roadside overpass, or hydraulic lift.

The process of replacing the filter yourself is not at all difficult, but it requires care on the part of the repairman. Seek help from a car repair shop specialist if you have never had to service your vehicle.

Filter design for Opel Astra J gasoline engine

Its only task is to clean gasoline from solid impurities. Of course, the quality of Russian gasoline for the most part leaves much to be desired, and, in addition to solid particles, it also contains various dissolved elements. But a device capable of separating them from gasoline has not yet been invented. This needs to be understood: if the actual octane number of the fuel does not correspond to the declared one, this situation cannot be corrected in any way.

The design of the fuel purification system on Opels with gasoline engines is quite simple. This unit is a metal (usually aluminum) cylinder in which two cellular elements are placed:

coarse cleaning element (sometimes called preliminary);
fine cleaning (or finishing).

Entering this unit, gasoline first passes through a pre-filter, which is a fine steel mesh - it retains only relatively large particles of contaminants. After this comes the finishing stage. It is carried out using high-quality 10-micron paper, on which very small contaminants are deposited.

Design of diesel fuel purification system

The design of a diesel engine fuel filter differs significantly from the design of a similar device in a gasoline engine. The fact is that in addition to the function of cleaning diesel fuel from solid contaminants, the unit has one more purpose: it retains the excess water contained in it.

The filter on the diesel Opel Astra also heats up the diesel fuel. This is done with the help of a special element that maintains the optimal temperature of the fuel before feeding it into the combustion chambers. Otherwise, paraffin crystals may form in the diesel fuel, which will simply clog the mesh of the main component of the system and the fuel supply will stop.

Opel Astra J Fuel Filter Replacement

Replacing the fuel filter Opel Astra J 1.6

In exchange for fuel

There is nothing complicated in the Opel Astra J filter, the main thing is to forget about safety. This note also applies to Opel Astra J with petrol power units 1. In the petrol model it is located in the lower part of the car, next to the petrol tank, in the diesel model. under the hood, to the left of the brake water tank. Opel Astra N gasoline pump. In turn, Opel Astra j TF gasoline is located under the bottom of the car, so it needs to be replaced. Does not require special abilities or special tools. A car needs a fuel filter to clean the gasoline or diesel from harmful parts, contaminants, and contaminants. This is especially true with regard to the criteria of our gas stations, when in large cities the fuel meets the declared characteristics, but in the country, at remote gas stations, the quality leaves much to be desired.

The gasoline resource of the fuel filter is not declared by the manufacturer and directly depends on the properties of the spilled fuel. They are usually attached to a part. If at least one of the symptoms is detected, you need to replace the Astra J fuel filter. Cancel reply Your email address will not be displayed. This note applies to Opel. aster

Jay with gasoline power units 1.

READ Where is the Engine Number of Renault Megane 2

This is especially true with regard to the criteria of our gas stations, when in large cities the fuel meets the declared characteristics, but in the country, at remote gas stations, the quality leaves much to be desired.

Diesel fuel purifiers must be changed every 30,000 km or every 2 years. And, of course, you need to know where the Opel fuel filter is located. aster

J. Replacing the Opel Astra fuel filter. FILTRR.RU. Your letter will not be published. Why? Opel Astra F won't start: You will need the same thing plus two gaskets to replace your car's diesel engine filter. fuel replacement

Astra
filter J.: It is because of this cleaning that all the fuel and the combustion chamber of the engine work for so long.

1) replacement

oil 2) replacing oil filter 3) replacing air filter Vital for the whole Opel family

Replacing fuel filter Astra J

Replacing the fuel filter

for Opel Astra

G with 1.7 DTI diesel engine.

Cancel reply Your email address will not be published. It is enough to drive the car into a hole or overpass, stock up on a Phillips screwdriver and a fuel drain tank. Original filter No. 1808246 carbon Opel Astra J 2011. Cosmo, replacement 600 rub. Diesel fuel purifiers should be changed every 30,000 km or every 2 years. You will still need to replace the diesel car filter plus two gaskets.

READ Replacement Low Beam Lamp Opel Astra H

Why? Opel Astra

F will not start: your letter will not be published. fuel replacement

J filters may be required in two cases: they are usually attached to the workpiece. Diesel fuel purifiers should be changed every 30,000 km or every 2 years. A fuel filter is necessary to clean gasoline or diesel fuel from harmful parts, contaminants, and contaminants. Thanks to this cleaning, all the fuel and the combustion chamber of the engine last so long. How to replace the oil filter in an Opel Astra J 1. Cancel reply Your email address will not be published.

You will still need to replace the diesel car filter plus two gaskets. And, of course, you need to know where the Opel fuel filter is located. aster

J. In the petrol model it is located at the bottom of the car, next to the gas tank, in the diesel model. under the hood, to the left of the brake fluid reservoir.

You will still need to replace the diesel car filter plus two gaskets. as a replacement for the oil filter on the Opel Astra J 1. If at least one of the symptoms is detected, then it is necessary to replace the Asters J fuel filter.

READ Changing the oil in the automatic transmission of a Volkswagen polo

And, of course, you need to know where the Opel fuel filter is located. Astra J. Replacing fuel without a fuel filter with Astra H, J. Opel Astra J. Opel Astra 2010. Gasoline Resource. fuel filter, it is not declared by the manufacturer and directly depends on the quality of the fuel being poured. You will still need to replace the diesel car filter plus two gaskets. replacement

Astra
fuel filter may be required in two cases:

Car selection

Brand

Model

Model type

Modification

Brand

Model

Model type

Modification

Brake fluids
Antifreeze
Power steering fluids
Hydraulic fluid
Oil additives
Lubricants
Motor oils
Car carpets
Crankcase and gearbox protection

Online store of spare parts for foreign cars. Auto parts in stock and on order.

AUTO3N.RU

Stock
Documentation
Confidentiality
Delivery
Contacts
Reviews
About Store
Payment
Return Policy
Spare parts for foreign cars
Franchise
Site updates
Articles
The educational center

Catalog

Auto parts
Auto chemical goods
Car cosmetics
Oils
Batteries
Autolight
Car accessories
Autoelectronics
Tool
Sports and recreation
Original catalogs
Maintenance catalog

Personal Area

To come in
Registration

Join us:

Rate our store

Online store of spare parts for foreign cars. Auto parts in stock and on order.

How to change the fuel filter correctly?

to d-110:

It is located under the rear row of seats and can be replaced together with the fuel pump.

d-110:
How to change the fuel filter correctly? #

What kind of engine do you have?

Look under the car, if the filter is not there, then it is assembled in the fuel pump module and can only be changed as a whole with the pump.

to d-110:

Depends on the engine type. excerpt from manual

And after what mileage is replacement recommended so as not to get stuck somewhere on the road?

to sergik72:

If you change everything that could cause you to get stuck somewhere on the road, then I think it’s cheaper to change the car..

to sergik72:

Change regularly every 10-15 thousand. At the same time, clean the fuel pump mesh.

to sergik72:

I support Raina. Replace every 10t or clean.

So it turns out I need to remove the pump and disassemble it every 10-15000? Is there a filter element? I have a gasoline engine.

sergik72:
So it turns out I need to remove the pump and disassemble it every 10-15000? Is there a filter element? I have a gasoline engine. #

The fuel filter built into the pump is designed to last the entire service life of the pump.

The mesh – the coarse filter – needs to be changed or cleaned.

Timely replacement of internal cleaners allows you to extend the life of your Opel passenger car. It is not advisable to carry out these manipulations yourself. It is more advisable to contact the experts of the Moscow auto service center “Autopilot”.

Where is it located, price, originals, analogues, articles

Engineers recommend inspecting the TF every 45,000 km. If your car is systematically filled with low-quality fuel, the filter replacement life will be reduced by several thousand kilometers. Natural sediment forms at the bottom of the tank, clogging the fibers of the cleaner.

The filter has a non-separable design and cannot be prevented or repaired.

Serial number/item	Price in rubles
Gasoline engines
H110WK	21-00083-SX	800 — 850
E59KP01 D78	PF3148	800 – 850
C10039ECO	PF3134	800 – 850
WK 512 (Astra N)	CFF100255	800 – 850
P 732x	L225/606	800 – 850
PU 8013 z	50014554	800 – 850
3ECO009	50013687	800 – 850
FS-2301	50013643	800 – 850
DE 3115	50013268	800 – 850
LF-1110	EFF026	800 — 850
Diesel engines
FC547E	PU 8013 z	From 900 – 1000
EP163	3ECO009	From 900 – 1000
C511 (Astra J)	DE 3115	From 900 – 1000
FE005z	CFF100255	From 900 – 1000
ADZ92310	L225/606	From 900 – 1000
ADG02325	50014554	From 900 – 1000
KX 78D	50013687	From 900 – 1000
KX 231D	EFF026	From 900 – 1000
180009510	C511 (Astra G)	From 900 – 1000
E59KP01 D78	ADZ92310	From 900 – 1000
C10039ECO	KX 231D	From 900 – 1000
*check the price with the manager at the time of purchase

unstable start of the power unit at different temperature conditions; increased fuel consumption; engine detonation at idle speed; acceleration is slower than usual; lumbago in the exhaust pipe; enriched or lean fuel mixture; The “Check Engine” light on the instrument panel is on.

Causes of filter clogging on Opel Astra (Opel Astra H)

operating the vehicle for longer than the recommended period before undergoing a scheduled technical inspection;
filling the tank with low-quality fuel, low-octane mixture for a long time;
purchase of non-original consumables;
the machine was left idle for a long time, in the “preservation” mode, as a result of which natural sediment formed in the circuit.

Fuel cell diagnostics on an Opel Astra

Stop the engine and open the hood.
Inspect the fuel circuit for damage.
Check the serviceability of the fuse (No. 14) of the mounting block, it is located under the dashboard, to the left of the steering wheel;
Check the tightness of the fuel supply line and make sure there are no fuel leaks.

If there are no comments on the integrity of the circuit, then proceed to replacing the TF.

"ASTRA": LOGICAL FORECAST

The costs of maintaining the basic model, although higher than those of some competitors (ZR, 2011, No. 12), remain quite acceptable. The sports modification of the OPC does not lend itself to such an accurate forecast, since a lot here depends on the driving ambitions of the previous owner. Of course, in general these cars get much more, especially in terms of brakes and clutch.

The compact van "Zafira V", built on the basis of the "Astra N", has a similar list of diseases, however, problems with the engine radiator and support bearings of the struts did not affect it, since there is a different set of components and assemblies, and some suspension parts have also been strengthened. Therefore, when you are convinced that cars built on the same platform suffer from the same birth defects, know that this is not always the case.

Thank you at Gostinichny Proezd (Moscow)

for assistance in preparing the material.

Opel Astra H (2004 - present): family traits

Replacing the fuel filter on an Opel Astra

Required materials and tools:

new filter: for gasoline or diesel engines;
rags;
flat head screwdriver;
TORX key to “8”;
pliers.

Step-by-step guide to replacing the TF with your own hands on an Opel Astra H:

We place the vehicle above the inspection hole.
We remove fuse No. 14 from the mounting block.
We start the engine, the unit runs until it stalls.
We insert the fuse into its original place again.
For a “diesel”: from the engine compartment side, unclip the fastenings of the pipes to the TF.
We remove the TF and install a new one.
We put on the clamp and fuel supply pipes.
For a gasoline engine: inside the car, in the back row, unclip the sofa seat.
We remove the sound insulation layer.
Unscrew the diagnostic window.
Remove the fuel pump assembly.
Let's disassemble the module into its component elements. Replace the fine filter with a new one.
We assemble the parts in reverse order.

Do-it-yourself fuel filter replacement is complete. Subsequent diagnostics after 40 - 45 thousand km.

The fuel purifier is subject to unscheduled diagnostics if the vehicle has been in storage mode for more than two years.

Instead of a summary: pros and cons

The possibility of additional purification of the fuel entering the fuel system seems positive. Another advantage is the low price of the project. Of course, no one will give guarantees. If there is a leak and the slightest spark, the possibility of a fire cannot be ruled out. In addition, with such innovations, you will no longer show up at an official car service center.

Attention! This article is not a guide to action, but only illustrates one of the ways to improve a car with your own hands.

Replacing the fuel filter on an Opel Astra

Required materials and tools:

new filter: for gasoline or diesel engines;
rags;
flat head screwdriver;
TORX key to “8”;
pliers.

Step-by-step guide to replacing the TF with your own hands on an Opel Astra H:

We place the vehicle above the inspection hole.
We remove fuse No. 14 from the mounting block.
We start the engine, the unit runs until it stalls.
We insert the fuse into its original place again.
For a “diesel”: from the engine compartment side, unclip the fastenings of the pipes to the TF.
We remove the TF and install a new one.
We put on the clamp and fuel supply pipes.
For a gasoline engine: inside the car, in the back row, unclip the sofa seat.
We remove the sound insulation layer.
Unscrew the diagnostic window.
Remove the fuel pump assembly.
Let's disassemble the module into its component elements. Replace the fine filter with a new one.
We assemble the parts in reverse order.

Do-it-yourself fuel filter replacement is complete. Subsequent diagnostics after 40 - 45 thousand km.

The fuel purifier is subject to unscheduled diagnostics if the vehicle has been in storage mode for more than two years.

Replacing an element in an Opel Astra J

Tools

To change the element to Astra J you will need:

pit or overpass;
Phillips screwdriver;
new filter;
container for draining fuel.

Replacement instructions

We drive onto a pit or overpass and support the front wheels with bricks. You also need to jack up the rear of the car.
Then you need to crawl under the bottom of the car and loosen the clamp securing your TF.
Place a pre-prepared container under the filter.
Next, disconnect the fuel hoses from the TF. Get ready to collect the poured gasoline.
When the fuel is clear, the filter can be removed.
We install a new element in place of the old TF and connect all the hoses.

Fuel filter for Opel Astra

In cars of the Opel family of modifications Astra N, Astra J, Astra G, fuel filters (hereinafter referred to as TF) are installed in the following order:

For the purpose of prevention, use the inspection channel, roadside overpass, or hydraulic lift.

Filter selection

If you are changing a filter device installed autonomously in a car, that is, not in a housing with a pump, then it is advisable to give preference to original spare parts from General Motors. The catalog number of the original filter is 813565.

But in practice, many analogues also effectively perform their functions.

Installation of filters from manufacturers is allowed:

Phoebe;Vicks;Craft;Profit;Starline;Premium.

For cars where the cleaner is installed together with the pump, the entire assembly will need to be replaced. The original pump is produced by Bosch, catalog number 0580314195.

Opel Astra H 1 9 fuel filter replacement

Replacing the fuel filter in Opel Astra cars yourself requires the car owner to know some of the features of the fuel system. So, in cars with a gasoline engine, the filter is a structural element of the fuel pump and is located in its housing. Because of this, the filter element cannot be changed separately. Replacement is carried out together with the fuel pump. This applies to petrol models Opel Astra A (1.6 l, 1.8 l), Opel Astra H (sedan and station wagon 1.2-1.8 l), H GTC (1.2-1.8 l), H Sport Hatch (1.2-1.8L), H Twin Top (1.6L, 1.8L). To select a fuel pump and fuel filter for these models, use the table that shows the manufacturers and catalog numbers of suitable spare parts. 1.

The fuel pump with fuel filter is located under the rear seat. We remove the seat cushion, fold back the carpet, and find the fuel pump cover. 2. Use a flat-head screwdriver to pry up the cover and remove it. 3. Disconnect the wiring harness. 4. By pressing the lock with a screwdriver, disconnect the fuel line fitting. 5. Use a rust removal liquid to treat the areas where the pump is secured with a retaining ring. 6. Turn the locking ring counterclockwise and remove it. 7. Pull out the fuel pump. 8. Having sealed the edges from below with sealant, we install a new fuel pump. 9. We assemble in reverse order. For diesel cars (A 1.7 l; G 1.7 l; 2.2 l; H 1.7 l) the filter is located separately from the injection pump. You can select a filter element from the table below.

The only tools we need are a screwdriver with an asterisk head. 1. The fuel filter is located under the hood on the driver's side closer to the windshield. Remove the ground terminal on the battery. 2. Use a screwdriver to unscrew the central bolt. Disconnect the connectors. 3. Remove the cover and take out the filter element. 4. Install a new one. 5. Close the lid, tighten the bolt, and connect the electrical connectors. This is how we learned how to change the fuel filter on an Opel Astra with diesel and gasoline engines. Continuing the previous topic, today I will focus on replacing the fuel filter (Opel Astra H, Z17DTH engine).

According to the maintenance schedule, this procedure is recommended to be carried out every 30 thousand kilometers, but at least once every 2 years, however, given the possibility of refueling with high-quality fuel, it is possible and more often, especially if non-original filters are used. Many people recommend changing the filter on the eve of winter before the onset of frost to improve fuel pumpability. The replacement procedure itself is quite simple and will not require more than 15 minutes. time. First of all, drain the fuel from the fuel filter. This is done simply, by analogy with draining condensate ( ). Once the fuel has been drained, you can begin replacing the filter. 1) Disconnect the fuel filter sensor and completely unscrew the screw securing the fuel filter cover. 2) Lift the lid, simultaneously turning its bottom side towards you, as shown in the photo.

This way, you don’t have to remove the fuel hoses; the cap can be turned on them quite easily. After the cover is turned, we lower it down, where it is fixed in this position by the filter housing. 3) Remove the filter element (it is mounted on a central rod that fixes its position inside the housing). 4) If there is contamination, clean the housing. We change two rubber gaskets (see photo, positions 1 and 2, included with the filter element). The gaskets can be pre-lubricated with diesel fuel

When working, pay attention to the fuel filter thrust spring (3), although it is firmly attached, you should be careful not to lose it. 5) Place a new fuel filter insert onto the fixing central rod and fill the filter housing with diesel fuel (first make sure that the fuel drain valve is completely closed)

The latter must be poured along the outer contour of the filter to prevent unfiltered fuel from entering the pump and injectors. 6) Put the cover in place, tighten the fastening screw, and connect the fuel filter sensor connector. Carefully wipe the filter housing and start the car. We make sure that there are no leaks through the valve and filter cover.

For Opel Astra with diesel engine

For diesel cars (A 1.7 l; G 1.7 l; 2.2 l; H 1.7 l) the filter is located separately from the injection pump. You can select a filter element from the table below.

KRAFT AUTOMOTIVE	1721601
BLUE PRINT	ADZ92310
BOSCH	1457429656
DELPHI	HDF513
COMLINE	EFF026
FILTRON	PM936
HOFFER	4229
JAPKO	3ECO009
KNECHT	KX 231D
KOLBENSCHMIDT	50013687
MANN-FILTER	P 732x
MASTER-SPORT	732X-KF-PCS-MS
MISFAT	F689
PURFLUX	C511
NPS	S133I02
OPTIMAL	FF-01218
VALEO	587902

The only tool we need is a screwdriver with an asterisk head.

1. The fuel filter is located under the hood on the driver's side closer to the windshield. Remove the ground terminal on the battery.

2. Use a screwdriver to unscrew the central bolt. Disconnect the connectors.

3. Remove the cover and take out the filter element.

4. Install a new one.

5. Close the lid, tighten the bolt, and connect the electrical connectors.

This is how we learned how to change the fuel filter on an Opel Astra with diesel and gasoline engines.

We have a diesel Opel Astra H under maintenance, on which the fuel filter needs to be replaced. We will show you clear photos and video instructions on how to do this yourself.

The fuel filter in this car is located under the hood, in a glass behind the engine. Disconnect all sensors:

It is convenient to remove the top tube with round pliers:

Unscrew the lid of the glass. It is often difficult to do this with your hands; you can take a small block, rest it against one of the edges and do not tap too hard with a hammer. A plumbing wrench would be ideal for replacing water filters.

We take out the old filter element, be prepared for diesel fuel to pour out of it, so prepare some kind of container or cloth in advance, do not forget to remove the old rubber seal:

The new one will come complete with a new filter, do not forget to replace it. Insert a new filter element:

And we reassemble in reverse order. Before starting the engine for the first time after replacing the fuel filter, turn the key several times partially so that the diesel fuel is pumped through the system and only then start the engine.

Video of replacing the fuel filter in Opel Astra H:

Backup video on how to replace the fuel filter in an Opel Astra N:

AutoPro experts know additional configurations:

LPG fuel filter (propane-butane): 6R0201511, 71753479, 881068, 3183600, MPG6009, S1836B, 253409110117, 10GAS2S, 2100693SX, PM99920, 7245262, FOGAS2S
Coarse fuel fine filter; Assembled: 813046, 818001, FC547E
Coarse fuel sediment filter insert, Coarse: 5818083, 013058180083A, 5818084, 5818083, 0818005, KX231D, SFPF7069, PE9361, F026402093, 013008180005A, 14574 31721, 818027, 0818027, KX231D, WF8405, 95516131, PU8013Z, 3058180083, 818005, P732X , 818531, 5818509, MD381, 30ECO009, 1457429656, L255606, MG1600, FA5762ECO, HDF513, A120019, 23305, PM936, C10039ECO, E59KPD78, E59KP01D78, FCE CO009, 110023, F300401, KX78D, 50013687, 1721601, KX78D, 63232, 260075, ELG5245 , 6148180000, DE3115, F689, C511, S6689N and others.
Standard equipment: 77362340, 0813035, 0813036, 0813569, 813035, 813036, 813569, 77362341, 77363600, 1345984080, 190697, PE982, 4807214, 2 6336, 1906C4, 013008130569A, 4708795, 93193621, 96816473, 93181377, 93179236, 60H2O00, 30ECO016, 1457070001 , C10026, KX208D, PU723X, 96816473, 110390, FCECO016, KX208D, S6H2ONE, C507, 70926336, 77365902, FG102, 93181377, PF1609, 260033, 818012 , 0818012, 15302543, 5514300, E148145, L409606, 50014136, SF9960, HDF608, BSG70130002 , J1338027 and others.

This spare part depends on the Opel Astra engine and its modifications

1.4 Z14XEP: 6R0201511, 71753479, 881068, 3183600, MPG6009, S1836B, 253409110117, 10GAS2S, 2100693SX, PM99920, 7245262, FOGAS2S
1.7 CDTI [Z17DTL, Z17DTH]: 813046, 818001, FC547E
1.7 CDTI [Z17DTL, A17DTR, Z17DTR, Z17DTH]: 5818083, 013058180083A, 5818084, 5818083, 0818005, KX231D, SFPF7069, PE9361, F026402093, 0130081 80005A, 1457431721, 818027, 0818027, KX231D, WF8405, 95516131, PU8013Z, 3058180083, 818005, P732X, 818531, 5818509, MD381, 30ECO009, 1457429656, L255606, MG1600, FA5762ECO, HDF513, A120019, 23305, PM936, C10039ECO, E59KPD78, E59KP01D7 8, FCECO009, 110023, F300401, KX78D, 50013687, 1721601, KX78D, 63232, 260075, ELG5245, 6148180000, DE3115, F689, C511, S6689N
1.9 CDTI [Z19DTH, Z19DT], 1.3 CDTI Z13DTH, 1.9 CDTI 16V Z19DTH, 1.9 CDTI Z19DTJ: 77362340, 0813035, 0813036, 0813569, 813035, 813036, 813569, 7736 2341, 77363600, 1345984080, 190697, PE982, 4807214, 26336, 1906C4 , 013008130569A, 4708795, 93193621, 96816473, 93181377, 93179236, 60H2O00, 30ECO016, 1457070001, C10026, KX208D, PU723X, 968164 73, 110390, FCECO016, KX208D, S6H2ONE, C507, 70926336, 77365902, FG102, 93181377, PF1609, 260033, 818012 , 0818012, 15302543, 5514300, E148145, L409606, 50014136, SF9960, HDF608, BSG70130002, J1338027

Spare part Fuel filter suitable for cars:

Fiat: Doblo minivan (119) , Doblo van (223) , Strada pickup (178E) , Panda hatchback (169A) , Idea minivan (350) , Ducato bus (244, Z) , Ducato van (244) , Ducato flatbed ( 244) , Croma station wagon (194) , Albea sedan (172) , Sedici SUV (189) , Punto hatchback (199) , Ducato van (250) , 500 hatchback (312) , Idea minivan (350)
Opel: Agila hatchback (H00) , Combo van , Corsa hatchback (F08, F68) , Vectra hatchback , Vectra sedan , Meriva minivan , Signum hatchback , Vectra station wagon , Combo minivan , Astra sedan (L69) , Astra station wagon (L35) , Tigra convertible (twin top) , Agila hatchback (H08) , Antara SUV (L07) , Zafira minivan (A05) , Astra hatchback (L48, L08)
Suzuki: Wagon R minivan (MM) , Ignis hatchback (FH) , SX4 hatchback (GY) , Swift hatchback (RS) , Splash hatchback , Swift hatchback (MZ, EZ) , SX4 hatchback , Vitara SUV (LY)
Citroen: Jumper flatbed (244) , Jumper bus (244, Z) , Jumper van (244) , Jumper flatbed (250) , Jumper bus (250) , Jumper van (250)
Subaru: Justy hatchback (G3X)
Lancia: Ypsilon hatchback (843) , Musa minivan , Musa minivan
Peugeot: Boxer bus (244, Z) , Boxer van (244) , Boxer flatbed (244) , Boxer bus (250)

Type, properties and volumes of working fluids

Fuel

Type
Gasoline engines	Unleaded gasoline is no worse than AI-95
Diesel engines	Diesel fuel with a cetane number of at least 49
Fuel tank volume	l
Astra models	52
Zafira models	58

Engine oil

Pay attention to the terms of warranty service for a new car regarding the use of synthetic motor oils!

Gasoline engines	All-season synthetic motor oil with viscosity OW-X, 5W-X, 10W-X according to ACEA A3-98/B3-98, where X= 30 and higher
Diesel engines	All-season synthetic motor oil with viscosity OW-X, 5W-X, 10W-X according to ACEA A3-98/B3-98 or A3-98/B3-98/B4-98, where X=30 and higher

Volume (with filter replacement)

engine's type	Volume, l
Z12XE/X12XE	3.5
Z14XE/X14XE	3.5
Z16SE/X16SE	3.5
Z16XE/X16XE	3.5
Z16XEP/X16XEP	3.5
Z18XE/X18XE	4.25
Z20LET/X20LET	4.25
X20XEV	4.25
X20XER	4.25
Z22SE/X22SE	5.0
Y17DT/X17DT	4.5
Y17DT (ECO)	4.5
Y20DTL	5.2
Y20DTH	5.2
Y22DTR	5.2

Cooling system

Coolant type	Mixture of soft water and antifreeze (1:1) to ensure frost resistance down to -40° C
Antifreeze	models from 10.2000 red/orange
models up to 9.2000 blue/green

Do not mix different types of antifreeze!

Volume

engine's type	Volume, l
Without air conditioner	With air conditioner
Z12XE/X12XE
Manual transmission	5.2	5.5
AT	—	—
Z14XE/X14XE
Manual transmission	6.3	6.6
AT	6.2	6.5
Z16SE/X16SE
Manual transmission	5.9	6.2
AT	5.8	6.1
Z16XE/X16XE
Manual transmission	6.3	6.6
AT	6.2	6.5
Z16XEP/X16XEP
Manual transmission	6.3	6.6
AT	6.2	6.5
Z18XE/X18XE
Manual transmission	6.5	6.8
AT	6.4	6.7
Z20LET/X20LET
Manual transmission	7.0
AT	—	—
X20XEV
Manual transmission	No data available
AT	No data available
X20XER
Manual transmission	No data available
AT	No data available
Z22SE/X22SE
Manual transmission	6.8	7.1
AT	6.6	6.9
Y17DT/X17DT
Manual transmission	7.1	7.1
AT	—	—
Y17DT (ECO)
Manual transmission	7.1	7.1
AT	—	—
Y20DTL/X17DTL
Manual transmission	—	—
AT	7.8	7.8
Y20DTH
Manual transmission	7.9	7.9
AT	—	—
Y22DTR
Manual transmission	7.9	7.9
AT	—	—

Type	ATF OPEL - 19 40 767 (No. 09 117 946)
Volume (when changing)	l
All models	4.0

Do not use Dexron II and Dexron III!

Window washer fluid

Type	Any proprietary windshield wiper fluid
Volume	l
Models with headlight lens washers	4.5
Models without headlight lens washers	2.3

What is a fuel filter

In any car, TF is an integral element of cleaning the fuel system. As stated above, this small, inconspicuous part determines the operation of the car as a whole, since it is responsible for the most important process. Namely, for purifying fuel from foreign impurities and moisture (pure gasoline can hardly be found at domestic gas stations).

Today we will tell you about the cleaning fuel cell in Opel Zafira cars. These cars are available in two versions: with gasoline and diesel engines. Cars with gasoline engines require careful and high-quality fuel filtration. This is necessary so that the injector nozzles do not become clogged for a long time, otherwise the car is guaranteed to have abnormal engine operation.

Used TF Opel Zafira with a gasoline engine

As for diesel modifications, these engines are no less sensitive to the quality of the fuel they fill. Diesel cleaning elements filter fuel in three stages:

pre-cleaning;
rough cleaning (continuation of preliminary);
fine fuel cleaning.

Diesel cars require a triple level of filtration due to the fact that D/T (diesel fuel) contains an order of magnitude more condensate or moisture than traditional gasoline. And since the mass of water is higher than the weight of the fuel, it settles at the bottom of the filter, but, thanks to its design, is optimally removed.

But if the filter component becomes clogged over time, then the water in it, accordingly, becomes more. When the humidity reaches a critical level, it must be drained from the filter. At this moment, a special sensor located at the very bottom of the diesel cleaning element housing will signal the driver about the problem via a light on the instrument panel. To the inconvenience of owners of diesel Opel Zafira, the fuel purifier is located in such a place that even if you want to drain the water from it, you still have to remove the filter housing.

New diesel TF for Opel Zafira

Where is the filter located

Now let's figure out where Opel Zafira diesel cars are installed. In vehicles with a gasoline engine, the TF is located under the bottom of the car, on the same level as the rear passenger seat, not far from the gas tank.

As for diesel modifications, the element is located behind a plastic shelf in the engine compartment, opposite the driver’s seat. If you cannot find this element in your car yourself, read about it in the operating instructions or contact your dealer for help.

Fuel filter in a 1.3 l diesel engine

1. The fuel filter is located on the partition in the engine compartment of the car, near the brake master cylinder reservoir.

2. Before starting work, stock up on old rags or newspapers and a container into which you can drain the remaining diesel fuel.

3. Open the hood and see the filter itself.

4. Use a screwdriver to pry up the locking tab...

... and disconnect the electrical connector of the fuel filter sensor.

5. Place a well-absorbing rag around the fuel filter housing, which will collect further spilled diesel fuel.

6. Using a suitable tool, for example, small pliers, press on the locking tabs of the fitting and at the same time pull to the side, ...

...disconnect the upper fuel line from the fuel filter housing cover.

Note: - When disconnecting the fuel line, fuel will leak out, be careful

— Be careful not to allow particles of dust or dirt to get into the disconnected fuel line. If necessary, plug the fuel line with a plug of the appropriate size.

7. Using your fingers or any other suitable tool on the plastic stops, unscrew the ring nut of the fuel filter housing cover.

8. Remove this nut.

When to change, what interior to install

To perform scheduled maintenance operations, there are regulations, as well as manufacturer recommendations. According to them, replacing the cabin filter of the Opel Astra II G heating and air conditioning system should be done every 15,000 kilometers or once a year.

Characteristic symptoms:

Windows often fog up;
the appearance of unpleasant odors in the cabin when the airflow is turned on;
deterioration of the stove and air conditioner;

They may make you doubt that the filter element is coping with its tasks and an unscheduled replacement will be required. In principle, these symptoms should be relied upon when choosing the correct replacement interval.

Suitable sizes

When choosing a filter element, owners do not always use products recommended by the car manufacturer. Everyone has their own reasons for this, some say that the original is unreasonably expensive. Some people in the region sell only analogues, so there is a need to know the sizes by which you can subsequently make a selection.

For DELPHI heater:

Height: 30 mm
Width: 199 mm
Length: 302 mm

For BEHR heater:

Height: 30 mm
Width: 236 mm
Length: 263 mm

As a rule, sometimes analogues for the Opel Astra II G can be a few millimeters larger or smaller than the original, there is nothing wrong with that. And if the difference is measured in centimeters, then of course it’s worth looking for another option.

Selecting an original cabin filter

The manufacturer recommends using exclusively original consumables, which, in general, is not surprising. They themselves are of good quality and are widely available in car dealerships, but their price may seem overpriced to many car owners.

Regardless of the configuration, on all second-generation Opel Astras (including the restyled version), the manufacturer recommends installing the following cabin air filters. Dust with DELPHI heater number 6808606 (Opel 68 08 606) or General Motors GM 13175553. And also dust for BEHR heater with item number 6808611 (Opel 68 08 611) or General Motors GM 93182436.

When choosing between a dust and carbon product, car owners are advised to use a carbon filter element. This filter is more expensive, but it cleans the air much better.

It is easy to distinguish - the paper filter accordion is impregnated with a carbon composition, and therefore has a dark gray color. The filter cleans the air flow from dust, fine dirt, germs, bacteria and enhances the protection of your lungs.

Which analogues to choose

In addition to simple cabin filters, there are also carbon filters that filter the air more effectively, but they are more expensive. The advantage of coal SF is that it does not allow foreign odors coming from the road (street) to penetrate into the car interior.

But this filter element also has a drawback - air does not pass through it well. GodWill and Corteco carbon filters are of fairly high quality and are a good replacement for the original.

However, in some retail outlets the price of the original cabin filter for the second generation Opel Astra may be greatly inflated. In this case, it makes sense to purchase a non-original consumable item. In particular, cabin filters are considered quite popular.

If the heater is DELPHI:

Conventional dust cabin filters

MANN-FILTER CU3054 – high-tech consumables from a well-known manufacturer
BIG Filter GB-9879 – popular brand, good fine cleaning
TSN 9.7.75 is a good manufacturer with an affordable price

Carbon cabin filters

MANN-FILTER CUK 3054 – high-quality and thick carbon coating
BIG Filter GB-9879/C – activated carbon
Raf filter RSTC005CHEY – normal quality, affordable price

If the heater is BEHR:

Conventional dust cabin filters

MANN-FILTER CU2757 – high-tech consumables from a well-known manufacturer
BIG Filter GB-9875 – popular brand, good fine cleaning
TSN 9.7.49 is a good manufacturer with an affordable price

Carbon cabin filters

MANN-FILTER CUK 2757 – high-quality and thick carbon coating
BIG Filter GB-9875/C – activated carbon
Ru54 CF-1055C – normal quality, affordable price

It makes sense to take a closer look at the products of other companies - they also specialize in the production of high-quality consumables for passenger cars:

Amd
Bosch
Denso
Filtron
Fortech
JS Asakashi
Knecht Mahle
Kortex
Masuma
Miles
Raf filter
SCT
Sakura
Stellox
Valeo
Zekkert
Nevsky filter

It is quite possible that sellers may recommend replacing the Astra II G cabin filter with non-original cheap substitutes with a much smaller thickness. They are not worth buying, since their filtering characteristics are unlikely to be at the proper level.

Where is it located, price, originals, analogues, articles

The filter has a non-separable design and cannot be prevented or repaired.

Signs of a clogged fuel filter on an Opel Astra

unstable start of the power unit at different temperature conditions;
increased fuel consumption;
engine detonation at idle speed;
acceleration is slower than usual;
lumbago in the exhaust pipe;
enriched or lean fuel mixture;
The “Check Engine” light on the instrument panel is on.

Causes of filter clogging on Opel Astra (Opel Astra H)

operating the vehicle for longer than the recommended period before undergoing a scheduled technical inspection;
filling the tank with low-quality fuel, low-octane mixture for a long time;
purchase of non-original consumables;
the machine was left idle for a long time, in the “preservation” mode, as a result of which natural sediment formed in the circuit.

Fuel cell diagnostics on an Opel Astra

Stop the engine and open the hood.
Inspect the fuel circuit for damage.
Check the serviceability of the fuse (No. 14) of the mounting block, it is located under the dashboard, to the left of the steering wheel;
Check the tightness of the fuel supply line and make sure there are no fuel leaks.

If there are no comments on the integrity of the circuit, then proceed to replacing the TF.

Removing air from the fuel system

17. Air will be removed from the system automatically when the ignition is turned on and the engine starts. If there is too little fuel in the filter, the engine may not start or the engine may stall shortly after starting. In this case, turn the ignition on and off three times, leaving it on for 15 seconds each time. When the ignition is turned on, the electric fuel pump is activated, with the help of which fuel circulates throughout the entire circuit of the fuel system, air is removed and the fuel filter is filled. Restart the engine - hold the ignition key until the engine starts, but no more than 30 seconds. If the engine does not start again, turn off the ignition and after a while repeat the air removal procedure.