What is the cabin filter responsible for and where is it located in the Kia Rio

One of the advantages of maximum unification of conveyor production is the similarity of maintenance procedures for different cars of the same manufacturer, down to the smallest detail. For example, having replaced the cabin filter on a Kia Rio of 2-3 generations yourself, you can find that it is changed in a similar way on other Kia passenger cars of the same class.

Considering that this procedure is more than simple, there is no need to resort to the help of a car service: you can simply change the cabin filter yourself even without any experience

Where is the cabin filter located in the Kia Rio?

The cabin filter is located in the Kia Rio, like in Sportage and Cerato, on the passenger side, behind the glove compartment. It is necessary to open the door; behind it there is an air duct outlet, onto which the cleaning element is attached. The air filter is located under the hood on the right side when facing the car.

You can also determine where the cabin filter is located on a gasoline Kia Rio using the technical manual that is included when purchasing the car.

Kia Rio X-Line service

The Kia Rio X Line is a sedan that has received a special off-road style, increased ground clearance and was specially adapted for Russia. Due to its increased off-road performance, the car is usually called a cross-hatchback. The car began to be produced at the Russian Hyundai plant in St. Petersburg. Compared to its predecessor, the Kia Rio, the X-Line has a higher ground clearance, slightly different dimensions (smaller length and slightly larger width) and a slightly changed appearance, mainly due to plastic body kits. The car is equipped with the same 1.4 and 1.6 liter engines, with a power of 100 and 123 horsepower. Maintenance of the Kia Rio X-line, respectively, takes place every 15,000 km or 1 year of car ownership.

List of works

TO-1 15,000 km (12 months)

At the first service of the Kia Rio X-line (which is TO-1, not to be confused with zero TO) it is necessary to replace:

Engine oil and oil filter
Cabin ventilation filter

And inspect the following components:

Body paint and decorative elements
Computer diagnostics of electronic systems
Exterior lights and indicators
Accumulator battery
Drive belts
Vacuum tubes and hoses
Engine crankcase ventilation hoses
Steering components
Air conditioning system, compressor
Engine cooling radiators, air conditioning
Fastening components and assemblies to the body and suspension
Front and rear suspension components
Pipes, hoses and connections of the brake system
Fuel lines, hoses and connections
Wheel drive shafts, wheel bearings, CV joints
Exhaust system
Tires (not including spare tire)
Disc brakes, discs and pads
Engine Coolant
Brake fluid
Engine air filter
Maintenance interval indicator, reset (if equipped)

Note: Mandatory inspection includes cleaning, adjustment and replacement if necessary.

TO-2 30,000 km (24 months)

During the second service, some additional items are added.

Replacement:

Engine oil and oil filter
Cabin ventilation filter
Brake fluid

Inspection and testing:

Body paint and decorative elements
Computer diagnostics of electronic systems
Exterior lights and indicators
Accumulator battery
Drive belts
Vacuum tubes and hoses
Engine crankcase ventilation hoses
Steering components
Air conditioning system, compressor
Engine cooling radiators, air conditioning
Fastening components and assemblies to the body and suspension
Front and rear suspension components
Pipes, hoses and connections of the brake system
Fuel lines, hoses and connections
Brake pedal
Parking brake
Fuel tank ventilation system and filler cap
Drum brakes, drums and shoes (if equipped)
Fuel filter
Air filter for fuel tank ventilation system (if equipped)
Automatic transmission fluid
Wheel drive shafts, wheel bearings, CV joints
Exhaust system
Tires (not including spare tire)
Disc brakes, discs and pads
Engine Coolant
Brake fluid
Engine air filter
Maintenance interval indicator, reset (if equipped)

TO-3 45,000 km (36 months)

Replacement:

Engine oil and oil filter
Engine air filter
Cabin ventilation filter
Battery "ERA-GLONASS" (if necessary)

Inspection, adjustment and testing:

Body paint and decorative elements
Computer diagnostics of electronic systems
Exterior lights and indicators
Accumulator battery
Drive belts
Vacuum tubes and hoses
Engine crankcase ventilation hoses
Steering components
Air conditioning system, compressor
Engine cooling radiators, air conditioning
Fastening components and assemblies to the body and suspension
Front and rear suspension components
Pipes, hoses and connections of the brake system
Fuel lines, hoses and connections
Wheel drive shafts, wheel bearings, CV joints
Exhaust system
Tires (not including spare tire)
Disc brakes, discs and pads
Engine Coolant
Brake fluid
Maintenance interval indicator, reset (if equipped)

TO-4 60,000 km (48 months)

The fourth thing on X-line is more extensive for checks, but not for replacements

Replacement:

Fuel filter
Air filter for fuel tank ventilation system (if equipped)
Brake fluid
Engine oil and oil filter
Cabin ventilation filter

Check and inspect the following items:

Body paint and decorative elements
Computer diagnostics of electronic systems
Exterior lights and indicators
Accumulator battery
Drive belts
Vacuum tubes and hoses
Engine crankcase ventilation hoses
Steering components
Brake pedal
Parking brake
Air conditioning system, compressor
Engine cooling radiators, air conditioning
Fuel tank ventilation system and filler cap
Fastening components and assemblies to the body and suspension
Front and rear suspension components
Pipes, hoses and connections of the brake system
Fuel lines, hoses and connections
Wheel drive shafts, wheel bearings, CV joints
Exhaust system
Tires (not including spare tire)
Disc brakes, discs and pads
Drum brakes, drums and shoes (if equipped)
Engine Coolant
Automatic transmission fluid
Engine air filter
Maintenance interval indicator, reset (if equipped)

TO-5 75,000 km (60 months)

Replacement:

Engine oil and oil filter
Cabin ventilation filter

Inspection and testing:

Body paint and decorative elements
Computer diagnostics of electronic systems
Exterior lights and indicators
Accumulator battery
Drive belts
Vacuum tubes and hoses
Engine crankcase ventilation hoses
Steering components
Air conditioning system, compressor
Engine cooling radiators, air conditioning
Fastening components and assemblies to the body and suspension
Front and rear suspension components
Pipes, hoses and connections of the brake system
Fuel lines, hoses and connections
Wheel drive shafts, wheel bearings, CV joints
Exhaust system
Tires (not including spare tire)
Disc brakes, discs and pads
Engine Coolant
Brake fluid
Engine air filter
Maintenance interval indicator, reset (if equipped)

TO-6 90,000 km (72 months)

Replacement:

Brake fluid
Automatic transmission fluid
Engine oil and oil filter
Engine air filter
Cabin ventilation filter
Battery "ERA-GLONASS" (if necessary)

Inspection and testing:

Body paint and decorative elements
Computer diagnostics of electronic systems
Exterior lights and indicators
Accumulator battery
Drive belts
Vacuum tubes and hoses
Engine crankcase ventilation hoses
Steering components
Brake pedal
Parking brake
Air conditioning system, compressor
Engine cooling radiators, air conditioning
Fuel tank ventilation system and filler cap
Fastening components and assemblies to the body and suspension
Front and rear suspension components
Pipes, hoses and connections of the brake system
Fuel lines, hoses and connections
Wheel drive shafts, wheel bearings, CV joints
Exhaust system
Tires (not including spare tire)
Disc brakes, discs and pads
Drum brakes, drums and shoes (if equipped)
Fuel filter
Air filter for fuel tank ventilation system (if equipped)
Engine Coolant
Maintenance interval indicator, reset (if equipped)

TO-7 105,000 km (84 months)

Engine oil and oil filter
Cabin ventilation filter

Examination:

Body paint and decorative elements
Computer diagnostics of electronic systems
Exterior lights and indicators
Accumulator battery
Drive belts
Vacuum tubes and hoses
Engine crankcase ventilation hoses
Steering components
Air conditioning system, compressor
Engine cooling radiators, air conditioning
Fastening components and assemblies to the body and suspension
Front and rear suspension components
Pipes, hoses and connections of the brake system
Fuel lines, hoses and connections
Wheel drive shafts, wheel bearings, CV joints
Exhaust system
Tires (not including spare tire)
Disc brakes, discs and pads
Engine Coolant
Brake fluid
Engine air filter
Maintenance interval indicator, reset (if equipped)

What types of cabin filters are there for Kia Rio?

In total, two types of cleaning elements can be distinguished:

For rough cleaning – designed to block coarse dust and dirt. Apart from the price advantage, it has such disadvantages as short service life and fragility.
For fine cleaning – blocks the smallest particles, prevents the penetration of external odors into the car. Made from synthetic materials.

There are also regular and carbon filters. The latter trap particles of harmful substances more efficiently.

How to replace the cabin filter element of a Kia Rio with your own hands?

The cabin filter is designed to clean the air that enters the cabin through the air intake openings from the street. The task is extremely relevant if you live in a large city. The concentration of exhaust gases on the road is high, and even with the windows closed, a huge amount of harmful substances enters the car. Air from the road contains a lot of substances hazardous to health:

tire dust;
small rubber particles;
asbestos from brake pads;
bacteria, viruses and plant spores.

If we talk specifically about the exhaust gas from a car, it includes more than 200 different toxic substances. These are oxides of carbon, sulfur and nitrogen, compounds of heavy metals, soot, hydrogen fluoride and much more. Even for a completely healthy person, a high concentration of exhaust gases is dangerous, but what can you say if you have asthma or other diseases of the respiratory system?

All these substances can lead to extremely unpleasant consequences: oxygen starvation, which causes headaches, shortness of breath and even a decrease in reaction speed. Nitrogen oxides lead to damage to the respiratory tract and lungs, while benzene, soot and formaldehyde lead to carcinogens. With constant exposure, chronic development of lung diseases is possible.

Experiments show that cabin filters are capable of trapping up to 99.5% of small and medium particles. However, as it gets dirty, of course, the part loses its effectiveness, which forces drivers to regularly replace it. We recommend not to neglect this, because your health directly depends on the quality of air in the cabin. In addition, replacing the cabin filter in the Kia Rio 3 takes just 5-7 minutes in a garage.

The part is installed on the air duct, which provides air flow into the cabin. Without the air duct, the driver and passengers could suffocate with the windows closed and the engine running.

The problem is that the air coming from the street is polluted and contains abrasive particles, the entry of which into the lungs can lead to asthma and other diseases. A cabin filter will help you avoid these dangers. He is also responsible for the operation of the air conditioner.

Before starting work, you will need to purchase the consumable item itself. The optimal solution would be to purchase a coal version, its catalog number is MS-6307.

From a technical point of view, even an inexperienced technician will not have any problems with how to remove the cabin filter on a Kia Rio and install a new one. The work can be done in your own garage, or just in the parking lot. The filter is located in the cabin, right behind the glove box.

open the glove compartment and empty it;
Find two plugs inside the compartment and remove them by first turning them counterclockwise. The glove box lid must be lowered and the right door open to create the space needed for work;

after removing the plugs, a shelf with a filter secured on both sides with clamps will become visible;

the latches are pulled towards themselves and carefully pressed out, the cover is removed;
the old filter element is removed;

a new part is inserted into the frame. If its linear dimensions are slightly wider than the frame, then the product can be trimmed along the edges. The arrow drawn on the fabric surface should be directed downwards during installation;

then all the parts are returned to their places in the reverse order; when closing, the plugs are turned until they click.

After watching how to change the cabin filter of a Kia Rio in the video, the driver can easily carry out the replacement operation on his own, without wasting time and nerves on visiting a car repair shop.

Which filter to choose: original or analogue

Before replacing the 4th generation Kia Rio cabin filter, the driver needs to decide between the original and analog spare parts:

The service life of high-quality products is allowed up to one and a half years. If you plan to do quiet and infrequent driving around the city, then this option is ideal.
If the issue of replacement does not frighten the car owner, then for the price of an original spare part you can purchase several products of lower quality and replace them every 3-4 months.

Also read: Replacing the clutch on a Kia Rio 3 - when required, tools and step-by-step instructions

Brands of original cleaning elements (some are supplied from the factory): NIPPART, Cangoo.

For pre-restyling models of 2012 (2009, 2010, 2011), only non-original spare parts for large filtration with article numbers MANN CU1828, VALEO 698681, TSN 9.7.117 are suitable.

How much does a filter cost?

Replacing the cabin filter for Kia Rio 2016 and 2022. release is not considered an overhead repair. The price ranges from 250 to 500 rubles for the analog coal version. The cost of a part with deep air purification starts from 600 rubles and reaches 1.5 thousand rubles.

Replacing the Rio 4 air filter

To change the engine air filter on a Kia Rio IV, you will need to unclip two latches, move the air housing cover back, lift it, and pull out the filter.

It is also advisable to plug the air intake hole and blow out the air filter housing with a stream of air.

To replace a new air filter, instead of the original - 28113H8100, you can take, for example, TSN 9.1.1565 (the price difference is 2 times). Everything is simple there, install it in the case, adjust it, and insert it into the guides on both sides and snap the case latches into place.

Signs of a clogged filter on a Kia Rio

You can understand that the Kia Rio 4 or Sportage cabin filter needs to be replaced by the following signs:

Extraneous unpleasant odors penetrate into the interior of the car, this is especially evident when the air conditioning is turned on: you can feel the soot, your nose itches from the dust.
The amount of dust on the dashboard and seats increases even with the windows closed.

Also, when the filter is clogged, the amount of air that enters the cabin is reduced. This leads to accelerated fogging of the windshield and side windows.

Choosing a cabin for Kia Rio 4

Purifiers targeted at China, not Europe, are supplied to Russia. Article number for cars produced before 2012 97133-D1000 (length - 22.5 cm , width - 20.5 cm , height - 2.8 cm ). The problem is that this cabin filter can only capture coarse dust. Therefore, it makes sense to buy a carbon element.

Carbon filter composition

ASIN: ASINFC 2753 - regular and ASINFC 2753C - carbon.
Fortech fs-150c - with coal.
RU54 CF944C - coal
KUK 0239 - with coal.

Anti-dust (regular) - base - made of corrugated paper, synthetic or cellulose fibers. Detains small particles, incl. flower pollen is inexpensive. However, it is powerless against unpleasant odors and volatile toxins. The standard replacement period is up to 30,000 km .

Cabin filters: regular dust filter (left) and carbon filter (right)

Carbon – consists of electrified synthetic fibers that stop the smallest ( up to 1 micron ) dust particles. Neutralizes up to 95% of toxins. Service life - up to 60,000 km , but the price is steep

Each Kia Rio 4 owner chooses a filter element that is compatible with his car and that suits his price.

Cabin filter diagnostics

To understand whether you need to change the cabin filter on a Kia Rio 2022 model or any other, you don’t have to contact hired specialists. The diagnostic process follows from the previously described signs of blockage:

Start the car and warm up the engine without turning on the heater.
Turn on the heating system at maximum power.
Place your hand against the air duct in the cabin.
If the blown air does not correspond to the set temperature, it means that the filter is clogged and it does not allow you to quickly heat the interior of the car.

Also read: Correct wheel bolt pattern for Kia Sid

Cabin filter Kia Rio X-line

I don’t think it’s worth saying that the cabin filter in the modern automotive industry is installed on all cars. The filter cleans the air entering the cabin and prevents unpleasant odors from penetrating. However, its resource is limited. We will tell you below which cabin filter to choose for the Kia Rio X-line.

Selection of cabin filter

Kia filter 97133D1000 is installed from the factory . The cost of the original filter is from 700 rubles. In addition to this filter, you can choose similar filters:

IBERIS IB772054 from 270 RUR
BERIS IB772054C from 350 rubles coal
AMD AMDFC753 from 200 RUR regular
GOODWILL AG464CFC from 300 rubles coal
JS ASAKASHI AC0239 from 400 RUR regular
SAKURA CA28380 from 550 RUR
GOODWILL AG463CF from 250 RUR

This is not the entire list of analogue filters, but only a part of them. When selecting a cabin filter for X line, we advise you to check with the seller or car service specialist whether this filter is suitable for your car.

How often to change the cabin filter on Rio X line

According to the manufacturer's regulations, the cabin filter should be changed every 15,000 km. However, we recommend replacing the filter based on operating conditions. In the summer, with regular use of the car, replace the filter element every 10,000 km.

How often should it be replaced?

The frequency with which the Kia Rio and Rio X-Line cabin filter changes depends on several factors:

selected model;
driving habits;
vehicle mileage.

If you add up all the nuances, then it is recommended to change the cleaning element once a year, provided that the car travels no more than 30 thousand km during this time and the majority of trips are within the city.

If most of the operation involves driving on dusty country roads, then even the highest quality cleaning element is recommended to be replaced after 15 thousand km.

There are recommendations that replacing the cabin filter for Kia Rio 2014, 2015 and later models should be done twice a year: before winter and before summer. However, it needs to be changed only when there is less dirt on the roads.

When is it time to change the interior?

Routine maintenance of the Kia Rio 4 (link to image source)
The regulations require changing the cabin filter in the Kia Rio 4 after 15,000 km . But in some cases this has to be done more often. For example, if in the summer heat you constantly drive with the windows closed and the air conditioning on. This mode of operation reduces by half .

Spring and autumn are periods with high air humidity. Dampness also shortens the life of the Kia Rio 4 cabin filter due to rotting of the materials.

The third reason for the rapid wear of an air purifier is frequent visits to industrial areas, where the filter layers become intensively clogged. In such conditions, interior consumables may require replacement after 5,000 km .

In such operating conditions of the car, it is reasonable to check the Kia Rio 4 cabin filter every 5 thousand km on the speedometer, and, if necessary, change it ahead of schedule.

Choosing a cabin for Kia Rio 4

Purifiers targeted at China, not Europe, are supplied to Russia.

Article number for cars produced before 2012 97133-D1000 (length - 22.5 cm , width - 20.5 cm , height - 2.8 cm ).

The problem is that this cabin filter can only capture coarse dust. Therefore, it makes sense to buy a carbon element.

ASIN: ASINFC 2753 - regular and ASINFC 2753C - carbon.
Fortech fs-150c - with coal.
RU54 CF944C - coal
KUK 0239 - with coal.

Cabin filters: regular dust filter (left) and carbon filter (right)

Each Kia Rio 4 owner chooses a filter element that is compatible with his car and that suits his price.

Signs of a clogged cabin filter

Fogging of the windshield is a sign of a dirty cabin air filter.
The instructions for using the cabin filter element indicate the standard service life provided that it is used under normal conditions. In fact, the consumable becomes clogged with dirt and loses functionality ahead of time. Therefore, we learn to identify signs of part failure. Let's list them .

The windshield often sweats.
Even with a carbon filter, unpleasant odors appear in the cabin of the Kia Rio 4.
The microclimate changes noticeably.
The heating system operates intermittently and temperature fluctuations are observed.
Ventilation is weak.
Dust began to quickly settle on the windshield and instrument panel
The filter element became obviously dirty - gray, brown, black.

There is no point in blowing out the cabin filter or washing it; this part must only be replaced. The low price of the consumable allows you to do this often.

Replacing the cabin filter Kia Rio 4

To replace the cabin filter in the Kia Rio 4 yourself, you should know where it is located. The air purifier is installed behind the glove compartment , and to get to it you need to do some dismantling. You don't need any tool for this. One flat screwdriver is enough. You can work both outdoors and in the garage, provided there is bright lighting.

The procedure is as follows:

The glove compartment is completely emptied of its contents.

Open the glove compartment and empty it of its contents.
In the 4th generation Kia Rio, the glove box mount is made differently than in the third generation. To lower the glove compartment, carefully squeeze the walls at the special slots.

To dismantle the glove compartment, you need to press on the walls of the glove compartment at the slots and pull it towards you.
The glove compartment goes down.

The glove compartment should “go down” and the cabin filter housing will be visible in front of us.
A rectangular container opens. It has a lid secured with a clip.

The cabin filter housing has a cover secured with a clip.
After removing the cover, it becomes possible to replace the old cabin filter with a new one.

Carefully remove the cover of the filter housing, remember how the old filter is installed and take it out.
When changing a part, you need to make sure that the arrow marked on the element points down.

We take a new filter and install it so that the arrow on it points down.
After reinstallation, you need to carefully check whether the filter is wrinkled and whether it is firmly in place.
The cover is put in place, the side latch is snapped into place. The cover is put into place and the side latch is snapped into place.
The last stage - the glove compartment is returned to its place, its limiters are installed. The glove compartment is returned to its place, its limiters are installed.

All work takes no more than 5-10 minutes . The most important and delicate job when replacing the air-cleaning filter in the Kia Rio 4 cabin, which requires care, is removing the restrictors in the glove compartment.

Conclusion

For the Kia Rio 4 itself, the cabin filter is of no value. But this detail is important for the well-being of the driver and passengers. Therefore, it is unwise to neglect it.

This inexpensive consumable protects people from both long-term health problems and immediate effects such as dizziness and slower reactions due to high concentrations of exhaust gases. This condition of the driver is fraught with the occurrence of emergency situations. Prevention of all these troubles is timely replacement of the cabin filter.

Video

Changing the cabin filter of Kia Rio 4Link to main publication

Consequences of a faulty filter

If the driver does not have time to change the cabin filter on the Kia Rio in time, every day more and more fuel combustion products, soot, dust, and various reagents that previously settled on the cleaning element will penetrate into the car’s interior. All these microelements will enter the human body, accumulating in the bronchi and lungs.

At first it will manifest itself as a sore throat and nose, but later it can develop into more severe cases, including allergic reactions and chronic diseases.

Replacement process

Can be performed either independently or in specialized centers. The main job is to diagnose the product, and this process is described above. Having removed the filter, install a new one if necessary, then perform the opposite steps to disassembly (described in the “diagnostics” section).

Well, as you yourself have already noticed, replacing the Kia Rio cabin filter is a fairly simple operation that you can do yourself. If you don’t have enough time to replace the filter yourself or you are not confident in yourself, then leave this task to the professionals (they will handle it in 15-30 minutes and no more).

Instructions for replacing the cabin filter on a Kia Rio

The process of dismantling the cleaning element does not require any special skills. Replacing the cabin filter for Kia Rio 2015 and subsequent years begins with preparation:

Wear gloves and any protective mask on your face to avoid inhaling harmful particles.
Prepare a flathead screwdriver, a clean damp cloth for wiping, and a new filter element.

Also read: Do-it-yourself oil change in automatic transmission Kia Sportage 3

If you have to change the cabin filter near your home in a Kia Rio, make sure that during the work you will not interfere with the movement of passing vehicles. Proceed to work following the instructions:

Stop the engine and open the glove compartment.
Use a screwdriver to remove the side door latches.
Gently press the plastic cover latches and pull it out.
Take out the old filter element, wipe the place where it is attached with a damp cloth, removing loose dirt and dust.
Insert the new filter, close it with the plastic panel until it clicks.
Place the glove compartment door back, securing it with the clips.

At this point, replacing the Kia Rio cabin filter can be considered successful; all that remains is to check the operation of the air conditioner. To facilitate the work process, you can watch the video instructions, which can be found freely available on the Internet.

How to choose

In order for replacing the Kia Rio cabin filter to bring you only positive emotions, you need to learn how to select the right parts. The most popular filters for this vehicle have the article number 971334L000.

Filter materials from the Hyundai brand are also suitable for the Kia Rio 3. Naturally, you can find cheaper options - non-original ones. The main criterion for their selection is that they must be suitable in size. But the quality of the work they perform, as well as the length of their service life, are in doubt. As the popular belief goes: “it’s better to pay once...” or “the miser pays twice.” Yes, in fact, it is better to purchase a high-quality spare part than a cheap one, which in three months will again require replacement and at the same time your costs (both financial and time).